Backhoe Battles Sweeten the Selection Construction Equipment

  • (PDF) Optimization of shovel-truck system for surface …

    Optimization of the loading and hauling fleet at Mamatwan open pit mine. From calculations, each truck is doing 3 cycle/h each truck is loading an average of 74.5t/cycle Tons moved/hour = 3 cycles/h x 74.5 t/cycle = 223.5 t/hr Hours needed to move the material =1 052.0 ton/219.0 t/h = 4.7 hour.

    Learn More
  • Optimization of the Excavator-and-Dump Truck Complex at

    Jun 26, 2018 · Optimization of the Excavator-and-Dump Truck Complex at Open Pit Mines – the Case Study Nuray Demirel 1, Amir Taghizadeh 1, Samer Khouri 2 and Ekaterina Tyuleneva 3 * 1 Mining Engineering Department, Middle East Technical University, Üniversiteler Mah., Dumlupınar Bulvarı, No: 1, 06800 Çankaya, Ankara, Turkey

    Learn More
  • (PDF) lecture 4 - mine transportation.pdf | Innocent Haule

    Discrete units haulers • Productivity of mobile equipments like trucks depends on the its carrying capacity and trips per hour which is a function of distance travelled, truck power and road conditions. • Rigid dump trucks are the backbone of haulage equipment for the worldwide mining industry.

    Learn More
  • A wholeness approach to open pit scheduling and optimization

    Apr 15, 2021 · A wholeness approach to open pit scheduling and optimization. The mining industry reports hundreds of billions of dollars in revenue every year. Most of this value is forecasted ahead of time and reported in the life-of-mine and budget plans. Mine planners evaluate and update several mine plans on a regular basis.

    Learn More
  • Computer Visualization of Optimality Criterion's Weighting

    Aug 08, 2020 · Computer visualization of optimality criterion's weighting coefficients is solved by modelling tools of MATLAB SIMULINK. The excavator's AC drive is studied as an electromechanical system. Thus the actual practical problem is studied – improvement of …

    Learn More
  • Investigation of Excavator Performance Factors in an Open

    Investigation of Excavator Performance Factors in an Open

    Learn More
  • PAPER OPEN ACCESS Optimization of Digging and Loading

    Mar 17, 2020 · the Komatsu HD 465-7 dump truck. The simulation results of the number of dump trucks needed based on production capacity is 17 units while based on queuing theory there are 17 units. Where the actual dump trucks used were 19 units. 1. Introduction In overburden stripping activities, PT. Artamulia Tata Pratama uses excavator backhoe and dump trucks

    Learn More
  • Optimization of Truck-Loader haulage system in an

    equipment is an important factor to consider when seeking to optimize the haulage system. This paper studies the haulage system of a mine which operates a fleet of three -Haul-DumpLoad (LHD) machines and three dump trucks, using SimMine simulation software. Its aim is to evaluate the effect of increasing

    Learn More
  • Productivity Improvement of Mining Haulage System with

    Verify the equipment required to haul the rock mass. and dump trucks are used to transport the ore and remove the overburden. Ore is carried to a processing plant or to the crushing and hauling facility located in the Medvezhy Ruchey open pit, and overburden is taken to dumps. The open pit optimization model allowed engineers to

    Learn More
  • (PDF) Optimization of shovel-truck system for surface mining

    In an open pit operation the trucks move from the shovels to the dump-crusher and back. equipment selection is a complex multiperson, multi-criteria decision problem. This paper describes

    Learn More
  • SciELO - Brasil - Multi-stage dumping sequence - a

    On the other hand, the green and red lines (with 3.5 km and 4.5 km from the pit exit to the temporary dump, respectively) represent the shorter haulage distance from the temporary dump to the final dump, with less frequent steps, causing a less sensitive required number of trucks.

    Learn More
  • Optimization of Truck-Loader haulage system in an

    equipment is an important factor to consider when seeking to optimize the haulage system. This paper studies the haulage system of a mine which operates a fleet of three -Haul-DumpLoad (LHD) machines and three dump trucks, using SimMine simulation software. Its aim is to evaluate the effect of increasing

    Learn More
  • General approach to distribute waste rocks between dump

    open pit mine. The maintenance cost to operating cost ratio in open pit mines is about 45%. Increasing truck size requires bigger bays and special tools. Due to the size and complexity of truck, down-time for regular maintenance and repair may be longer, and, in the case of unscheduled repairs, the time consumed for troubleshooting may be

    Learn More
  • Optimization of the Excavator-and-Dump Truck Complex at

    (PDF) Optimization of open pit haulage cycle using a KPI

    Learn More
  • Estimation of Hydraulic Backhoes Productivity for

    For example, the overburden removing complex launched in 2008 at Taldinsky coal open pit mine includes hydraulic excavator Hitachi EX-3600 (backhoe) with a bucket capacity of 20 m 3, wheel bulldozer CAT-834 and caterpillar bulldozer CAT D-10, dump truck …

    Learn More
  • A Vehicles for Open-Pit Mining with Smart Scheduling

    clouds for certain computationally complex multi-target optimizing algorithms. Smart manufacturing and operating management for a mine open-pit unmanned truck dispatching device will help with the powerful computing capacity of edge computing [13]. The open-pit scheduling system requires, as shown in

    Learn More
  • A PRACTICAL SIMULATION APPROACH FOR AN EFFECTIVE …

    shovel to load the material into dump trucks. When the trucks reach the dumping point, the trucks dump the material into the dumping port (only one, as well). With the enhanced calculation capacity of computers, it is possible to simulate complex operations in open pit mines.

    Learn More
  • Optimization of the loading and hauling J fleet at

    Investigation of Excavator Performance Factors in an Open

    Learn More
  • Integrating machine learning, optimization and simulation

    Nov 26, 2019 · St. ľphane Alarie and Michel Gamache. 2002. Overview of Solution Strategies Used in Truck Dispatching Systems for Open Pit Mines. International Journal of Surface Mining, Reclamation and Environment 16, 1 (2002), 59-76. [5] Robert F. Subtil, Diego M. Silva, and Julio Cesar Alves. 2011. A Practical Approach to Truck Dispatch for Open Pit Mines.

    Learn More
  • Investigation of Excavator Performance Factors in an …

    Jun 01, 2018 · The article considers the use of excavator-and-dump truck complex optimization as a criterion for the average weighted size of pieces of exploded rock mass, which allows determining the optimal parameters of each of the associated technological processes, their costs, as well as the total costs of the technology as a whole.

    Learn More